食品科学 ›› 2010, Vol. 31 ›› Issue (2): 17-21.doi: 10.7506/spkx1002-6630-201002004

• 工艺技术 • 上一篇    下一篇

野生异叶爬山虎果皮红色素提取及稳定性研究

卜晓英1,陈晓华2,麻明友1   

  1. 1.吉首大学 林产化工工程湖南省重点实验室 .2.张家界市环境保护局
  • 收稿日期:2009-02-25 修回日期:2009-10-30 出版日期:2010-01-15 发布日期:2010-12-29
  • 通讯作者: 卜晓英 E-mail:xyingbu@163.com
  • 基金资助:

    湖南省科技厅计划项目(2005JT1075);湖南省教育厅研究计划项目(05C139)

Extraction and Stability of Pigment from Wild Grown Parthenocissus heterophylla (Bl.) Merr

BU Xiao-ying1,CHEN Xiao-hua2,MA Ming-you1   

  1. 1. Hunan Provincal Key Laboratory of Forest Products and Chemical Engineering, Jishou University, Zhangjiajie 427000, China;
    2. Zhangjiajie Environmental Protection Bureau, Zhangjiajie 427000, China
  • Received:2009-02-25 Revised:2009-10-30 Online:2010-01-15 Published:2010-12-29
  • Contact: BU Xiao-ying1, E-mail:xyingbu@163.com

摘要:

采用水溶液提取野生异叶爬山虎果皮中红色素,通过L16(45)正交试验对野生异叶爬山虎果皮中红色素提取条件进行优化,对提取液进行喷雾干燥,并对粉末红色素进行各种检测。结果表明,影响红色素提取的显著因素是温度与料液比,其次是提取溶剂和提取时间;通过喷雾干燥法能有效地得到粉末状红色素;粉末状红色素所含有害成分含量极低;该色素受pH 值的影响较大,易溶于水、酸性乙醇与酸性甲醇,难溶于三氯甲烷、乙酸乙脂等;研究食品中几种常见的共存物、Mg2+、Ca2+、Cu2+、Fe2+、Na+、温度对红色素稳定性的影响。

关键词: 异叶爬山虎, 红色素, 提取, 理化性质

Abstract:

Organic solvent extraction technique was employed to extract pigment from wild grown Parthenocissus heterophylla (Bl.) Merr. Single factor method combined with orthogonal array design was used to analyze the effects of four crucial parameters (namely material/liquid ratio, temperature, extraction time and extraction solvent type) on Parthenocissus heterophylla (Bl.) Merr pigment extraction. Subsequently, the extracted pigment was spray dried and tested for physiochemical properties and meanwhile, its stability was also evaluated. Results showed that the yield of the pigment (expressed as the absorbance at 512 nm) was affected significantly by extraction temperature and material/liquid ratio, whereas extraction solvent type and extraction time had no significant effects. Red Parthenocissus heterophylla (Bl.) Merr pigment powder was obtained after spray drying. Lower contents of harmful heavy metal elements were observed in the pigment, which exhibited poor pH stability and was soluble in water, acidic ethanol and methanol but not soluble in chloroform and ethyl acetate. The thermal stability of the pigment at acidic pH was stronger than at neutral or alkaline pH. Hyperchromic effects of Mg2+, Ca2+, Cu2+, VC, sodium benzoate and potassium sorbate were observed, while the color of the pigment was changed with the existence of Fe2+, and the existence of Na+ exhibited no effect on the color of the pigment.

Key words: Parthenocissus heterophylla (Bl.) Merr, pigment, extraction, physiochemical quality

中图分类号: