提高冷冻酸面团中乳酸菌抗冻性的研究

食品科学 ›› 2006, Vol. 27 ›› Issue (10): 151-154.

提高冷冻酸面团中乳酸菌抗冻性的研究

段立, 黄卫宁, 堵国成

江南大学食品学院食品科学与安全教育部重点实验室；江南大学生物工程学院工业生物技术教育部重点实验室

出版日期:2006-10-15 发布日期:2011-11-16

Study on Improvement of Cryopreservation of Lactic Acid Bacteria in Frozen Sourdough Starters during Freezing and Frozen-Storage

DUAN Li, HUANG Wei-Ning, DU Guo-Cheng

1.Key Laboratory of Food Science and Safety, Ministry of Education, School of Food Science and Technology, Southern Yangtze University, Wuxi 214036, China;2. Key Laboratory of Industrial Biotechnology, Ministry of Education, School of Biotechnology, Southern Yangtze University, Wuxi 214036, China

Online:2006-10-15 Published:2011-11-16

摘要/Abstract

摘要： 本文用植物乳杆菌和短乳杆菌混合发酵酸面团,将酸面团置于-80℃下速冻,随后置于-20℃下冻藏,冻藏时间30d,来研究不同添加剂对酸面团中乳酸菌抗冻性的影响。通过选用添加剂还原型谷胱甘肽(GSH)、果糖、谷氨酸钠、VC,同时做空白样(未加添加剂)实验,随后测量经过冻藏酸面团中菌体总的存活率和产酸能力,每隔10d测定一次。采用平板菌落计数法测定经过冻藏酸面团中菌体总的存活率,产酸能力采用pH计测定。经冻藏后菌体总的存活率降低,产酸能力降低。结果表明GSH、果糖、谷氨酸钠、VC对低温下的菌体都有保护作用,但GSH和谷氨酸钠比其它添加剂更能有效地在低温下保护植物乳杆菌和短乳杆菌,提高菌体总的存活率和产酸能力。冷冻10、20、30d后添加GSH的样品中菌体总存活率分别为92.69%、86.62%、84.98%,添加谷氨酸钠的样品中菌体总存活率分别为86.65%、68.35%、64.34%。使用这两种添加剂后菌体生长的迟滞期短,产酸快。并且冷冻时间越长,保护效果越明显。本研究为冷冻酸面团的生产打下了理论基础。

关键词: , 冷冻, 酸面团, 乳酸菌, 抗冻性

Abstract: Sourdough was prepared with wheat flour and water with lactobacillus (Lactobacillus plantruam and Lactobacillus brevis) at the same portion (109 CFU/ml), incubated at 30℃ with the mixture of suspensions of L. plantruam and L. brevis. Beforethat, Lactobacillus was suspended in the water at 30℃. In order to measure the influence of different additives on the Lactobacillus at freezing temperature, four additives (glutanthione, fructose, sodium glutamate, and ascorbic acid) were added during freezing (-80℃) and frozen-storage (-20℃). The control sample was made without additive. The viability was measured every 10 days throughout 30 days of the frozen-storage period. The pH of the two strains before and after freezing and frozen-storage were measured by a pH meter. The viability was valued by the enumeration of CFU (colony-forming units) and the acidification activity. All additives showed a protective effect on cell viability as compared to saline solution, especially after freeze-drying procedures. Glutanthione was the most effective additives in preserving bacterial viability. After freezing and frozen-storage the viability of the strains was respectively 92.69%(10 days), 86.62%(20 days) and 84.98%(30 days). And the viability of the strains protected by sodium glutamate was respectively 86.65%(10 days), 68.35%(20 days) and 64.34%(30 days). The lag phase of the strains after using glutanthione and sodium glutamate was shorter, and the acidification activity was stronger. Moreover, the effect was better as the frozen-storage was prolonged. The research built a foundation for the development of frozen sourdough production.

Key words: , freeze； sourdough； lactic acid bacteria； cryopreservation；

段立, 黄卫宁, 堵国成. 提高冷冻酸面团中乳酸菌抗冻性的研究[J]. 食品科学, 2006, 27(10): 151-154.

DUAN Li, HUANG Wei-Ning, DU Guo-Cheng. Study on Improvement of Cryopreservation of Lactic Acid Bacteria in Frozen Sourdough Starters during Freezing and Frozen-Storage[J]. FOOD SCIENCE, 2006, 27(10): 151-154.

[1]	曹雪慧，王甄妮，白鸽，朱丹实，吕长鑫. 超声波对不同孔隙率水果冻结特性的影响[J]. 食品科学, 2021, 42(7): 128-133.
[2]	罗昆，曹伟超，马子琳，武盟，Omedi Jacob OJOBI，郑建仙，黄卫宁，李宁，Filip ARNAUT. 高产植酸酶乳酸菌发酵对黑豆面包蛋白质品质及烘焙特性的影响[J]. 食品科学, 2021, 42(6): 111-117.
[3]	朱寒剑，李雷兵，郑心，李琴，穆杨，徐宁，胡勇，吴茜，柳志杰，李玮，汪超，周梦舟. 乳酸菌生物膜形成调控及在食品中的应用研究进展[J]. 食品科学, 2021, 42(5): 296-304.
[4]	吴宇桐，张潮，陈倩，孔保华. 超声辅助浸渍冷冻对冻藏期间猪肉水饺肉馅水分分布和品质特性的影响[J]. 食品科学, 2021, 42(3): 128-135.
[5]	孙悦，刘佳伊，陈璐，杜宏，白凤翎，吕欣然，张德福，郭晓华，励建荣. 抗耐药性大肠杆菌乳酸菌的筛选及抑菌机制[J]. 食品科学, 2021, 42(2): 121-127.
[6]	罗强，李幸洋，陈炼红，张明，刘巧，张大伟，罗璠. 传统发酵泡菜中乳酸菌种群组成及优良菌株产酸耐酸特性分析[J]. 食品科学, 2021, 42(2): 158-163.
[7]	龙峻瑶，张均伟，黄丽，夏宁，滕建文，韦保耀，廖佳珺，郑培英. 六堡茶乳酸菌多样性及其降胆固醇特性分析[J]. 食品科学, 2021, 42(18): 58-64.
[8]	刘璐，吴江丽，杨金桃，唐忠月，曾雪峰. 发酵鱼酱酸产GABA乳酸菌的分离筛选及发酵特性[J]. 食品科学, 2021, 42(18): 73-79.
[9]	白琳，茹先古丽·买买提依明，王旭光，徐兵洁，阿不都乌甫尔·若孜，艾合买提江·艾海提. 5 种乳酸菌对库车小白杏发酵液理化性质及感官评价的影响[J]. 食品科学, 2021, 42(16): 83-88.
[10]	颜旭，王方杰，吴祖芳，翁佩芳. 乳酸菌发酵胡柚汁对小鼠肥胖的调节作用[J]. 食品科学, 2021, 42(15): 167-173.
[11]	潘海博，覃璐琪，黄燕婷，梁晓琳，黄国宏，聂梦琳，饶川艳，梅丽华，李全阳. 人工神经网络结合遗传算法优化保护剂提高罗伊氏乳杆菌抗冻性能[J]. 食品科学, 2021, 42(14): 70-77.
[12]	刘欣，陈梅春，刘芸，郑雪芳，陈峥，王阶平，刘波. 乳酸菌发酵过程发酵液脂肪酸组生态位的异质性[J]. 食品科学, 2021, 42(14): 110-120.
[13]	赵珊，仲伶俐，李曦，雷欣宇，郑幸果，郭灵安，雷绍荣，周虹，黄世群，冯俊彦. 超高效液相色谱测定冷冻研磨甘薯植株中酚酸及其分布[J]. 食品科学, 2021, 42(12): 222-232.
[14]	丁丽丽，吕欣然，高永悦，崔晓玲，王小咪，白凤翎，仪淑敏，郭晓华. 鱼肠道中抗氧化活性乳酸菌的筛选及鉴定[J]. 食品科学, 2021, 42(10): 127-132.
[15]	武盟，曹伟超，程新，马子琳，罗昆，徐岩，黄卫宁，李宁，高铁成. 高产α-半乳糖苷酶乳酸菌发酵对鹰嘴豆酸面团生化特性及其面包烘焙品质的影响[J]. 食品科学, 2021, 42(10): 146-153.