3种马铃薯改性淀粉的理化性质及结构分析

食品科学 ›› 2013, Vol. 34 ›› Issue (1): 109-113.

3种马铃薯改性淀粉的理化性质及结构分析

方国珊1，谭属琼2，陈厚荣1，刘雄1,*

1.西南大学食品科学学院 2.福建师范大学闽南科技学院

收稿日期:2011-11-06 修回日期:2012-12-04 出版日期:2013-01-15 发布日期:2013-01-07
通讯作者: 方国珊 E-mail:f11gs@126.com
基金资助:
重庆市科技攻关计划项目资助项目

Physico-chemical Properties and Structural Analysis of Modified Potato Starch

Received:2011-11-06 Revised:2012-12-04 Online:2013-01-15 Published:2013-01-07
Contact: Guo-Shan FANG E-mail:f11gs@126.com

摘要/Abstract

摘要： 以马铃薯淀粉为材料，制备氧化淀粉、醋酸酯淀粉、氧化醋酸酯淀粉，比较其理化性质，并通过红外光谱(FT-IR)、电子扫描显微镜(SEM)等对其结构进行分析。结果表明：氧化淀粉、醋酸酯淀粉、氧化醋酸酯淀粉比原淀粉透明度高、流动性好、附着力强、涂抹性好。FT-IR实验表明氧化淀粉有羧基的特征吸收峰，而氧化醋酸酯淀粉酯化改性过程中有醋酸酯基团的生成。SEM扫描实验显示氧化淀粉的外形比较规整多为球状或椭球状，表面较光滑；醋酸酯淀粉颗粒形状未发生大的改变，但规整度很差；氧化醋酸酯淀粉颗粒完整，表面粗糙，低取代度的酯化反应仅发生在淀粉颗粒表面。

关键词: 马铃薯淀粉, 氧化, 醋酸酯, 氧化醋酸酯, 理化性质

Abstract: Modified starches were prepared from native potato starch through introducing acetic ester groups and their structural characteristics were analyzed by FT-IR and SEM. Oxidized potato starch, potato starch acetate and oxidized potato starch acetate exhibited better transparency, adhesiveness and spreadability when compared to native potato starch. FT-IR analysis revealed the presence of characteristic absorption peak of carboxyl groups in oxidized potato starch and the formation of acetate groups in oxidized potato starch acetate. SEM observation showed the spherical or ellipsoidal shape and smooth surface of oxidized potato starch, no detectable change in the shape of potato starch acetate granules, but with poor regularity, and intact oxidized potato starch acetate granules with a low degree of substitution as a result of estertification on their rough surfaces.

Key words: modified starch, oxidization, acetate, oxidized-acetate, physico-chemical properties

中图分类号:

TS23

方国珊1，谭属琼2，陈厚荣1，刘?雄1,*. 3种马铃薯改性淀粉的理化性质及结构分析[J]. 食品科学, 2013, 34(1): 109-113.

参考文献

[1]Idris Azni, Inane Bulent, Hassan Mohd Nassir.Overview of waste disposal and landfills/dumps in asian countries[J].Material Cycle and Waste Manage in Asia,2004,(6):104-110
[2]杨秀芳.造纸工业中的氧化淀粉[J].黑龙江造纸,2004,(4):43-44
[3]陈永胜，李新华，吕晓秀，等.玉米氧化淀粉的制备及性能研究[J].内蒙古民族大学学报,2003,18(6):511-513
[4]钱大均，杨光.醋酸酯淀粉的制备及性质研究[J].中国粮油学报,2007,27(2):49-52
[5]李新法，刘培义，陈金周，等.玉米淀粉醋酸酯的研制[J].包装工程,2008,29(5):18-19
[6]王彦斌.淀粉基乳胶内墙涂料的可行性研究[J].西北民族大学学报,2004,2(25):21-23
[7]丽娟，蓝仁华.木薯淀粉在建筑涂料中的应用[J].涂料工业,2004,34(8):52-54
[8]廖文波，杨欣静，蓝仁华.氧化醋酸酯淀粉粘合剂的制备与性能改善[J].包装工程,2009,30(1):58-62
[9]张雯，张盛贵，张会翔，等.马铃薯氧化淀粉的工艺优化[J].甘肃农业大学学报,2008,4(43):131-134
[10]Naotsugu Nagasawa, Toshiaki Yagi, Tamikazu Kume,et al.Radiation crosslinking of carboxymethyl starch[J].Carbohydrate Polymers,2004,(58):109-113
[11]谭属琼，刘丽平，陈厚荣，等.氧化醋酸酯马铃薯淀粉的制备工艺研究[J].食品科学,2011,32(14):40-46
[12]何传波.甘薯淀粉磷酸单酯的制备及凝沉性质的研究[J].食品科学,2004,30(9):108-112
[13]张华东，赵怡丽.粉末涂料与附着力[J].中国涂料,2005,20(7):9-11
[14]Gerhard P, Schwall, Richard Safford, Roger J.Westcott, et al..Production of very - high - amylose patato starch by inhibition of SBE A and B[J].Nature Biotechnology,2002,(18):551-554
[15]Fang J M, Fowler P A.The Prepartion and Characterisation of a Series of Chemically Modified Potato Starches[J].Carbohydrate Polymers,2002,47:245-
[16]戴小敏，左秀锦，刘袖洞，等.醋酸酯淀粉的溶解性能、形貌与 XRD 结构分析[J].化学研究与应用,2004,16(1):61-62
[17]张光华，王卓妮，朱军峰.氧化醋酸酯淀粉的制备及其在表面施胶中的应用[J].中国造纸,2006,25(3):15-18