LSA-7树脂分离纯化爬山虎果实红色素工艺优化

doi:10.7506/spkx1002-6630-201112025

食品科学 ›› 2011, Vol. 32 ›› Issue (12): 111-114.doi: 10.7506/spkx1002-6630-201112025

LSA-7树脂分离纯化爬山虎果实红色素工艺优化

卜晓英，董爱文，陈晓华

1.吉首大学林产化工工程湖南省重点实验室 2.张家界市环境保护局

出版日期:2011-06-25 发布日期:2011-06-10
基金资助:
湖南省科技厅计划项目(2008TP4008-3；2005JT1075)；湖南省教育厅科技项目(05C139)；湖南省高校“林产资源化学与林化产品开发”科技创新团队支持计划项目

Optimization of Purification Process for Red Pigment from Parthenocissus tricuspidate Fruits by LSA-7 Resin Adsorption

BU Xiao-ying1，DONG Ai-wen1，CHEN Xiao-hua2

1. Key Laboratory of Forest Products Chemical Engineering of Hunan Province, Jishou University, Zhangjiajie 427000, China； 2. Zhangjiajie Environmental Protection Bureau, Zhangjiajie 427000, China

Online:2011-06-25 Published:2011-06-10

摘要/Abstract

摘要： 对常用的10种大孔吸附树脂应用于爬山虎熟果红色素分离效果考察，其中LSA-7型树脂具有最佳分离效果。进一步优化LSA-7树脂动态吸附分离红色素的条件和应用紫外分光光度法和高效液相色谱法对分离纯化得到的红色素进行品质检测。结果表明：在温度30℃、进样质量浓度30mg/mL时流经LSA-7吸附柱的红色素溶液体积达到两倍床层体积，树脂吸附接近饱和；当洗脱剂以3BV/h通过吸附床时，洗脱下来的红色素纯度大于96.7%，所含色素成分与薄层硅胶H分离的该色素成分一致，因此LSA-7树脂完全适合工业化动态生产爬山虎熟果红色素。

关键词: 爬山虎, 红色素, LSA-7树脂, 动态吸附

Abstract: Ten kinds of commonly used macroporous resin were compared for their effectiveness in purifying crude red pigment obtained from Parthenocissus tricuspidate fruits by fractional solvent extraction. It was found that LSA-7 resin had the best purification performance. Further, operating conditions for purifying red pigment from Parthenocissus tricuspidate fruits by dynamic adsorption onto LSA-7 resin column were optimized and UV spectrophotometry and HPLC were used to analyze red pigment samples. The adsorption of LSA-7 resin almost reached its saturation under the following conditions: temperature of 30 ℃, sample concentration of 30 mg/mL and sample loading amount of 2 BV. Elution at a flow rate of 3 BV/h resulted in a red pigment purity of more than 96.7%. Moreover, the resulting pigment composition was the same as that obtained by thin layer silica gel H separation. Therefore, LSA-7 resin is suitable for industrial dynamic production of red pigment from Parthenocissus tricuspidate fruits.

Key words: Parthenocissus tricuspidate, red pigment, LSA-7 resin, dynamic adsorption

中图分类号:

卜晓英，董爱文，陈晓华. LSA-7树脂分离纯化爬山虎果实红色素工艺优化[J]. 食品科学, 2011, 32(12): 111-114.

BU Xiao-ying，DONG Ai-wen，CHEN Xiao-hua. Optimization of Purification Process for Red Pigment from Parthenocissus tricuspidate Fruits by LSA-7 Resin Adsorption[J]. FOOD SCIENCE, 2011, 32(12): 111-114.

[1]	范三红，王娇娇，李佳妮，白宝清. 辣椒红色素和辣椒碱体内抗氧化活性及降血脂功能[J]. 食品科学, 2021, 42(5): 201-207.
[2]	范三红，王娇娇，白宝清，张锦华. 三相盐析萃取分离辣椒红色素和辣椒碱及不同辣椒品种的聚类分析[J]. 食品科学, 2020, 41(20): 270-277.
[3]	牛瑜琦，马晓斐，李挥，张敬轩，高文惠. QuEChERS-超高效液相色谱-串联质谱法快速测定辣椒红色素中9 种非食用色素[J]. 食品科学, 2020, 41(10): 311-316.
[4]	岳建明，杨强，肖潇，尹胜，张婵，王成涛，胡济美，赵吉兴. 铵盐对紫色红曲霉合成代谢红曲色素及桔霉素的影响[J]. 食品科学, 2016, 37(5): 102-107.
[5]	滕文卓，张敏，李国英. 天然染色可食胶原膜的制备及表征[J]. 食品科学, 2016, 37(2): 7-12.
[6]	卜晓英1，卜小庆2，杨勇3. 蘘荷红色素分离纯化及喷雾干燥工艺优化[J]. 食品科学, 2014, 35(22): 104-108.
[7]	胡金燕，郑华*，张雯雯，李坤，刘兰香，张弘. 脂溶性胭脂虫红色素的制备及表征[J]. 食品科学, 2014, 35(12): 29-34.
[8]	董楠1，王强2，雷丹丹1，刘宏3，刘嘉1，赵国华1,4,*. 胭脂萝卜红色素热处理及贮藏过程中降解动力学[J]. 食品科学, 2013, 34(5): 67-71.
[9]	李鹏霄1，茆广华2，赵婷2，邹烨2，任月娜3，白石琦1，吴向阳3，仰榴青3,*. 火棘果红色素的提取及抗氧化活性[J]. 食品科学, 2013, 34(17): 116-119.
[10]	谢姣，王华，谈安群，任庭院，张银，李元虎. 葵花壳红色素提取方法[J]. 食品科学, 2012, 33(4): 128-133.
[11]	李帅，蒋建泉，胡癸峰，张应烙. 杨梅渣红色素酸水提取和精制工艺[J]. 食品科学, 2012, 33(24): 21-25.
[12]	许润，刘建华，杨广成，李计龙，杨迺嘉. 鸡血藤红色素的提取与基本性质分析[J]. 食品科学, 2012, 33(10): 107-110.
[13]	董楠1，宋会歌1，刘嘉1，赵国华1,2,*. 咖啡酸对胭脂萝卜红色素辅色作用及稳定性的影响[J]. 食品科学, 2011, 32(7 ): 61-64.
[14]	李彩霞，焦扬*，高海宁，张芬琴，袁海琴. 一株细菌红色素的理化性质研究[J]. 食品科学, 2011, 32(7 ): 156-161.
[15]	孙月娥，邵颖，陈安徽，刘晓娟，樊美珍. 一株串珠镰刀菌胞内红色素稳定性及部分生理活性研究[J]. 食品科学, 2011, 32(19): 54-59.

LSA-7树脂分离纯化爬山虎果实红色素工艺优化

Optimization of Purification Process for Red Pigment from Parthenocissus tricuspidate Fruits by LSA-7 Resin Adsorption

RichHTML

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价