苹果渣结合预乳化稻米油对低脂猪肉丸品质的影响

doi:10.7506/spkx1002-6630-20181130-353

食品科学 ›› 2020, Vol. 41 ›› Issue (12): 54-59.doi: 10.7506/spkx1002-6630-20181130-353

苹果渣结合预乳化稻米油对低脂猪肉丸品质的影响

王正荣，阮夏青，马文涛，康壮丽，朱明明，赵圣明，马汉军

（1.河北工程大学生命科学与食品工程学院，河北邯郸 056021；2.河南科技学院食品学院，河南新乡 453003；3.国家猪肉加工技术研发专业中心，河南新乡 453003）

出版日期:2020-06-25 发布日期:2020-06-22
基金资助:
河南省重大科技专项（161100110600）；河南科技学院大学生“百农英才”创新专项（BNYC2016-2-04）；河南省高等学校重点科研项目（18A550007）；河南省科技厅科技攻关项目（182102110091）

Effect of Apple Pomace Combined with Pre-emulsified Rice Oil on the Quality of Low-Fat Pork Meatballs

WANG Zhengrong, RUAN Xiaqing, MA Wentao, KANG Zhuangli, ZHU Mingming, ZHAO Shengming, MA Hanjun

(1. College of Life Sciences and Food Engineering, Hebei University of Engineering, Handan 056021, China; 2. School of Food Science and Technology, Henan Institute of Science and Technology, Xinxiang 453003, China; 3. National Pork Processing Technology Research and Development Professional Center, Xinxiang 453003, China)

Online:2020-06-25 Published:2020-06-22

摘要/Abstract

摘要： 为开发低脂肉制品，利用苹果渣结合预乳化稻米油部分替代猪背膘，研究其对低脂猪肉丸持水力和持油能力、色泽、质构、粗脂肪、流变特性以及感官评价的影响。结果表明：苹果渣结合预乳化稻米油部分替代猪背膘能提高低脂肉丸的硬度和咀嚼性，且可有效地降低其粗脂肪含量。随着苹果渣添加量的增加，低脂肉丸持水力、持油能力和黄度值呈增加的趋势。流变学特性分析结果表明：随着苹果渣添加量的增加其储能模量逐步增加，但是苹果渣添加量为3%时，其红度值和感官评分有降低的趋势，当苹果渣添加量为2%时，其感官评分（74.02±1.04）与对照组（75.92±0.85）最为接近，且差异不显著（P＞0.05）。因此结合经济因素，综合考虑，添加2%的苹果渣结合预乳化稻米油部分替代猪背膘的猪肉丸效果最佳。

关键词: 苹果渣, 预乳化, 低脂, 猪肉丸, 流变

Abstract: In order to develop low-fat meat products, the effect of partially replacing pork back fat with apple pomace combined with pre-emulsified sesame oil on the water holding/oil binding capacity, color, texture profile analysis (TPA), fat content, dynamic rheology, and sensory properties of pork meatballs was examined. The results showed that partial replacement of pork back fat with apple pomace combined with pre-emulsified sesame oil increased the hardness and chewiness, and reduced the crude fat content of meatballs. An ascending trend in the water holding/oil binding capacity and yellowness (b* value) was observed with increasing level of apple pomace. The rheological analysis demonstrated that the storage modulus G’ progressively increased with increasing level of apple pomace. However, both a* value and sensory evaluation score increased firstly and then decreased with increasing level of apple pomace up to 3%. The sensory score of the sample with 2% apple pomace was closest to the control meatballs, 74.02 ± 1.04 versus 75.92 ± 0.85, without any significant difference between them (P > 0.05). From an economic perspective, 2% apple pomace combined with pre-emulsified sesame oil was determine to be optimum for partially replacing pork back fat in meatballs.

Key words: apple pomace, pre-emulsified oil, low-fat, meatballs, dynamic rheology

中图分类号:

TS251.1

王正荣，阮夏青，马文涛，康壮丽，朱明明，赵圣明，马汉军. 苹果渣结合预乳化稻米油对低脂猪肉丸品质的影响[J]. 食品科学, 2020, 41(12): 54-59.

WANG Zhengrong, RUAN Xiaqing, MA Wentao, KANG Zhuangli, ZHU Mingming, ZHAO Shengming, MA Hanjun. Effect of Apple Pomace Combined with Pre-emulsified Rice Oil on the Quality of Low-Fat Pork Meatballs[J]. FOOD SCIENCE, 2020, 41(12): 54-59.

[1]	戚明明，任志尚，张光耀，贺壮壮，汪陈洁，张东亮，马成业. 挤压处理对豌豆淀粉的流变特性和体外消化率的影响[J]. 食品科学, 2021, 42(9): 55-63.
[2]	孙聪，郑明珠，许秀颖，蔡丹，刘美宏，曹勇，刘景圣. 玉木耳多糖对杂粮粥糊化、流变及老化特性的影响[J]. 食品科学, 2021, 42(8): 46-51.
[3]	宋春勇，洪鹏志，周春霞，陈艾霖，冯瑞. 大豆油和预乳化大豆油对金线鱼鱼糜凝胶品质的影响[J]. 食品科学, 2021, 42(8): 90-97.
[4]	刘忠博，耿升，蒋兆景，杨伟，刘本国. 基于环糊精的食品级Pickering乳液构建[J]. 食品科学, 2021, 42(6): 24-30.
[5]	姜姝，腾军伟，刘振民，张娟. 超高压处理对再制奶油干酪质构、流变学特性及微观结构的影响[J]. 食品科学, 2021, 42(5): 84-91.
[6]	王佳玉，陈凤莲，吴迪，汤晓智. 谷氨酰胺转氨酶对全麦面团特性及微观结构的影响[J]. 食品科学, 2021, 42(4): 51-57.
[7]	曹云刚，李颖，郭安琪，熊幼翎. 绿茶提取物添加及脂肪替代对低脂猪肉香肠品质及脂质氧化稳定性的影响[J]. 食品科学, 2021, 42(4): 94-99.
[8]	李宁宁，李钊，赵圣明，马汉军，张文振，康壮丽，朱明明，王正荣，何鸿举. 地皮菜添加量对鸡胸肉糜凝胶特性的影响[J]. 食品科学, 2021, 42(2): 53-59.
[9]	张书文，Eman Saad RAGAB，张雨萌，王童，逄晓阳，芦晶，蒋士龙，冷友斌，吕加平. 超声处理改善羊乳理化性质及其酶凝胶流变学特性[J]. 食品科学, 2021, 42(17): 84-90.
[10]	陈晨，汪佳佳，王立健，庄昕波，陈银基. 油脂预乳化液替代脂肪对乳化肠品质的影响[J]. 食品科学, 2021, 42(16): 8-13.
[11]	李秀秀，尚静，杨曦，薛佳，郭玉蓉. 多糖的增稠、胶凝及乳化特性研究进展[J]. 食品科学, 2021, 42(15): 300-308.
[12]	樊红秀，李艳霞，刘婷婷，刘鸿铖，王大为，张艳荣. 挤出处理对玉米粉流变及其成膜特性的影响[J]. 食品科学, 2021, 42(15): 89-98.
[13]	蔡淼，郝晓娜，罗天淇，陈超，曹永强，杨贞耐. 植物乳杆菌YW11胞外多糖对酸乳加工特性的影响[J]. 食品科学, 2021, 42(14): 39-45.
[14]	林楠，肖瑜，杨新标，郑明珠，潘楚，秦智欣，李学震，张泸月，刘景圣. 麦芽糖对糯性谷物淀粉糊化和流变性质的影响[J]. 食品科学, 2021, 42(10): 1-7.
[15]	张海璐，黄翔，杨燃，安凤平，艾明艳，黄群. 蛋白质氧化对羊肉糜流变与凝胶特性的影响[J]. 食品科学, 2020, 41(8): 8-13.

苹果渣结合预乳化稻米油对低脂猪肉丸品质的影响

Effect of Apple Pomace Combined with Pre-emulsified Rice Oil on the Quality of Low-Fat Pork Meatballs

RichHTML

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价