乳清蛋白-低聚木糖复合脂肪替代品的制备及其于再制干酪中的应用

doi:10.7506/spkx1002-6630-20230109-055

食品科学 ›› 2023, Vol. 44 ›› Issue (20): 53-61.doi: 10.7506/spkx1002-6630-20230109-055

乳清蛋白-低聚木糖复合脂肪替代品的制备及其于再制干酪中的应用

李倩文，梁影，王晓楠，张川，刘治芹，陈树兴，吕明琪

（1.河南科技大学食品与生物工程学院，河南洛阳 471023；2.中原食品实验室，河南漯河 462333；3.漯河食品职业学院，河南漯河 462333）

出版日期:2023-10-25 发布日期:2023-11-07
基金资助:
北京市科技计划项目（Z201100008020005）

Preparation of Whey Protein-Oligosaccharide Complex and Its Application as Fat Substitute in Processed Cheese

LI Qianwen, LIANG Ying, WANG Xiaonan, ZHANG Chuan, LIU Zhiqin, CHEN Shuxing, LÜ Mingqi

(1. College of Food and Biological Engineering, Henan University of Science and Technology, Luoyang 471023, China; 2. Food Laboratory of Zhongyuan, Luohe 462333, China; 3. Luohe Food Vocational College, Luohe 462333, China)

Online:2023-10-25 Published:2023-11-07

摘要/Abstract

摘要： 以乳清蛋白与低聚木糖为原料，采用湿法糖基化法制备糖基化乳清蛋白，分析以其为基质制备脂肪替代品的优势，又进一步探究了该脂肪替代品在减脂再制干酪中的代脂效果。结果表明：最佳制备条件为6%低聚木糖与乳清蛋白在85 ℃下反应2 h。在此条件下，糖基化乳清蛋白接枝度为（29.28±1.53）%，出现褐变现象，与未糖基化乳清蛋白相比，其二级结构中α-螺旋、β-折叠、β-转角及无规卷曲含量发生改变，持水性及持油性分别提高60.18%、103.97%，乳化性与乳化稳定性分别提高30.81%、13.57%，且表面更光滑，在pH 7时表面疏水性较高，较未糖基化乳清蛋白提高了1.48 倍，再于10 000 r/min下剪切10 min，中值径达到7.57 µm左右，且溶液稳定性明显提高，此时的糖基化乳清蛋白已具备模拟脂肪的条件；将其替代再制干酪中60%黄油时，减脂再制干酪的硬度相较于全脂再制干酪显著减小（P＜0.05），融化性显著增大（P＜0.05），但弹性、咀嚼性等质构特性及亮度L*无显著差异（P＞0.05），且感官加权总分与全脂再制干酪相当。该研究结果证明了该糖基化乳清蛋白具备作为脂肪替代品开发减脂食品的潜力，且在一定程度上保证了产品的良好品质。

关键词: 乳清蛋白；低聚木糖；糖基化；脂肪替代品；减脂再制干酪

Abstract: Glycosylated whey protein (GWP) was prepared from whey protein and xylooligosaccharide by wet glycosylation method. Its advantages for use as a fat substitute were analyzed, and the application of this fat substitute in reduced-fat processed cheese was explored. The results showed that the optimal preparation conditions were determined as: xylooligosaccharide concentration of 6%, reaction temperature of 85 ℃ and reaction time of 2 h. The grafting degree of GWP prepared using these conditions was (29.28 ± 1.53)%, and a browning phenomenon occurred during the preparation process. Compared with whey protein, the contents of α-helix, β-fold, β-turn and random coil structures changed in GWP, and the water and oil-holding properties increased by 60.18% and 103.97%, respectively; the emulsifying capacity and emulsion stability increased by 30.81% and 13.57%, respectively. The surface of GWP was smoother. The surface hydrophobicity at pH 7.0 was 2.48 times higher than that of whey protein. After shearing at 10 000 r/min for 10 minutes, the median particle diameter of GWP was 7.57 µm, and the stability of the solution was obviously improved, so that GWP could be used to simulate fat. The hardness of reduced-fat processed cheese with 60% butter replacement by GWP was significantly lower than that of full-fat processed cheese (P < 0.05), and the meltability increased significantly (P < 0.05), but the texture characteristics such as elasticity, chewiness and brightness value (L*) were not significantly different from those of full-fat processed cheese (P > 0.05), and the total sensory score was equivalent to that of full-fat processed cheese. These results proved that the glycosylated whey protein has a potential application as a fat substitute in reduced-fat food while guaranteeing that the quality of the product is good.

Key words: whey protein; xylooligosaccharide; glycosylation; fat substitutes; reduced-fat processed cheese

中图分类号:

TS252.53

李倩文，梁影，王晓楠，张川，刘治芹，陈树兴，吕明琪. 乳清蛋白-低聚木糖复合脂肪替代品的制备及其于再制干酪中的应用[J]. 食品科学, 2023, 44(20): 53-61.

LI Qianwen, LIANG Ying, WANG Xiaonan, ZHANG Chuan, LIU Zhiqin, CHEN Shuxing, LÜ Mingqi. Preparation of Whey Protein-Oligosaccharide Complex and Its Application as Fat Substitute in Processed Cheese[J]. FOOD SCIENCE, 2023, 44(20): 53-61.

[1]	贾丽丽王家栩李嘉欣王志敏张密霞马春丽. 牛羊乳比例对Malatya干酪成熟品质及抗氧化特性的影响[J]. 食品科学, 0, (): 0-0.
[2]	陈臣，田同辉，刘政，于海燕，袁海彬，田怀香. 基于感官评价、GC-IMS和GC-MS的中式酸凝奶酪挥发性风味比较[J]. 食品科学, 2023, 44(16): 228-236.
[3]	陈臣田同辉刘政于海燕袁海彬田怀香. 基于感官评价、GC-IMS和GC-MS的中式酸凝奶酪挥发性风味比较 [J]. 食品科学, 0, (): 0-0.
[4]	李红娟李梦凡袁玉京陈紫阳朱广潮李丹李洪波于景华. 再制干酪乳化过程中理化、功能特性及微观结构的变化[J]. 食品科学, 0, (): 0-0.
[5]	王泽张岩陈炼红. Edam牦牛干酪成熟过程中品质变化及蛋白质降解[J]. , 0, (): 0-0.
[6]	王亚东韩颢颖韩兆盛王绒雪王姣杨智杰曹雁平王蓓. 新鲜乳扇贮存期间关键香气组分变化分析[J]. 食品科学, 0, (): 0-0.
[7]	宋国顺宋雪梅梁琪. 不同NaCl添加量对牦牛乳硬质干酪成熟过程中生物胺产生的影响[J]. 食品科学, 0, (): 0-0.
[8]	余鹏飞马春丽王家栩贾丽丽. 钾盐替代和附属发酵剂对切达干酪品质的影响[J]. 食品科学, 0, (): 0-0.
[9]	宋雪梅宋国顺梁琪张炎张忠明. 牦牛乳硬质干酪成熟过程中生物胺与细菌菌落结构分析[J]. , 0, (): 0-0.
[10]	宋雪梅，宋国顺，梁琪，张炎，张忠明. 牦牛乳硬质干酪成熟过程中生物胺与细菌群落结构分析[J]. 食品科学, 2021, 42(23): 27-33.
[11]	姜姝腾军伟刘振民张娟. 超高压处理对再制奶油干酪质构、流变学特性及微观结构的影响[J]. , 0, (): 0-0.
[12]	姜姝，腾军伟，刘振民，张娟. 超高压处理对再制奶油干酪质构、流变学特性及微观结构的影响[J]. 食品科学, 2021, 42(5): 84-91.
[13]	王姣，许凌云，张晋华，王小雨，艾娜丝，王蓓，曹雁平. 不同成熟时间切达奶酪中挥发性香气成分及其电子鼻判别分析[J]. 食品科学, 2020, 41(20): 175-183.
[14]	王姣，许凌云，张晋华，边冉，王蓓，曹雁平. SPME-GC-MS和GC-O鉴定3 种不同生产工艺马苏里拉奶酪的特征香气物质[J]. 食品科学, 2020, 41(18): 210-217.
[15]	杨静, 梁琪, 宋雪梅, 张炎. 牦牛乳与荷斯坦牛乳硬质干酪的抗氧化特性比较[J]. 食品科学, 2020, 41(15): 15-21.

乳清蛋白-低聚木糖复合脂肪替代品的制备及其于再制干酪中的应用

Preparation of Whey Protein-Oligosaccharide Complex and Its Application as Fat Substitute in Processed Cheese

RichHTML

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价