低温等离子体活化水与介质阻挡放电联合处理对草莓冷杀菌效果及品质的影响

doi:10.7506/spkx1002-6630-20210830-393

食品科学 ›› 2022, Vol. 43 ›› Issue (17): 105-116.doi: 10.7506/spkx1002-6630-20210830-393

低温等离子体活化水与介质阻挡放电联合处理对草莓冷杀菌效果及品质的影响

赵莹，严龙飞，严文静，章建浩

（1.南京农业大学食品科学技术学院，江苏南京 210095；2.南京苏曼等离子体工程研究院，江苏南京 210095）

出版日期:2022-09-15 发布日期:2022-09-28
基金资助:
“十四五”国家重点研发计划重点专项（2021YFD2100503-3）

Effect of Combined Cold Plasma-Activated Water and Dielectric Barrier Discharge Treatment on the Sterilization and Quality of Strawberry

ZHAO Ying, YAN Longfei, YAN Wenjing, ZHANG Jianhao

(1. College of Food Science and Technology, Nanjing Agricultural University, Nanjing 210095, China; 2. Nanjing Suman Plasma Engineering Research Institute, Nanjing 210095, China)

Online:2022-09-15 Published:2022-09-28

摘要/Abstract

摘要： 草莓采后微生物污染目前已成为物流过程中安全品质控制的研究热点，本研究以菌落总数为响应值，在等离子体活化水（plasma activated water，PAW）制备时间、水杨酸浓度、浸泡时间，介质阻挡放电（dielectric barrier discharge，DBD）低温等离子体工作电压、处理时间和工作频率的单因素试验基础上，采用Plackett-Burman试验筛选出对草莓菌落总数影响高度显著的因素，并通过Box-Behnken试验探究PAW及DBD联合处理对草莓冷杀菌效果及感官品质的影响。结果表明：草莓表面菌落总数随PAW制备时间的延长及水杨酸浓度的增大呈先减少后趋于平缓的趋势；随DBD工作电压的增大及处理时间的延长呈逐渐减少的趋势，但超过60 kV或150 s时草莓出现褪色甚至表观破损；浸泡时间及DBD工作频率对菌落总数无显著影响（P＞0.05）；对草莓菌落总数影响高度显著的因素主次顺序为水杨酸浓度＞PAW制备时间＞DBD工作电压（P＜0.001），且水杨酸浓度和DBD工作电压的临界值均随PAW制备时间延长呈线性下降的趋势；回归优化结果为PAW制备时间96 s、水杨酸浓度1.1 mmol/L、DBD工作电压46 kV，此条件下草莓表面的菌落总数由3.64（lg（CFU/g））降至0.83（lg（CFU/g）），杀菌率达99.8%，在20 ℃贮藏8 d内明显抑制表面微生物生长，有效维持生鲜品质，延长保鲜期。

关键词: 草莓；低温等离子体冷杀菌；水杨酸；菌落总数；贮藏期；生鲜品质

Abstract: Postharvest microbial contamination of strawberries has become a topical issue for safety and quality control in the logistics process. In this study, the effect of combined cold plasma-activated water (PAW) and dielectric barrier discharge (DBD) treatment on the sterilization and quality of strawberries was explored. One-factor-at-a-time experiments were carried out to investigate the effect of PAW preparation time, salicylic acid concentration, and soaking time as well as DBD working voltage, time and frequency on the total bacterial count (TBC) on the surface of strawberries. The significant variables affecting the response variable were determined using Plackett-Burman (PB) design and were optimized using Box-Behnken design. Results showed that the TBC on the surface of strawberries decreased first and then leveled off with increasing PAW preparation time and salicylic acid concentration, while it continuously decreased with increasing DBD working voltage and time. Nevertheless, when DBD working voltage and time exceeded 60 kV and 150 s, respectively, the appearance of fruit color was faded and even damaged. Soaking time and working frequency had no significant effect on the TBC (P > 0.05). Besides, salicylic acid concentration, PAW preparation time and DBD working voltage were the significant variables affecting the TBC (P < 0.001), ranked in decreasing order of importance. The critical values of salicylic acid concentration and DBD working voltage both showed a linear downward trend with PAW preparation time. The optimum values of PAW preparation time, salicylic acid concentration and DBD working voltage were found to be 96 s, 1.1 mmol/L and 46 kV, respectively. Under these conditions, the TBC decreased from 3.64 (lg (CFU/g)) to 0.83 (lg (CFU/g)) and the sterilization rate was 99.8%. The combined treatment could obviously inhibit the growth of microorganisms at 20 ℃ for 8 days, effectively maintain the quality and extend the shelf life of strawberries .

Key words: strawberry; cold plasma sterilization; salicylic acid; total bacterial count; storage period; fresh fruit quality

中图分类号:

TS255.36

赵莹，严龙飞，严文静，章建浩. 低温等离子体活化水与介质阻挡放电联合处理对草莓冷杀菌效果及品质的影响[J]. 食品科学, 2022, 43(17): 105-116.

ZHAO Ying, YAN Longfei, YAN Wenjing, ZHANG Jianhao. Effect of Combined Cold Plasma-Activated Water and Dielectric Barrier Discharge Treatment on the Sterilization and Quality of Strawberry[J]. FOOD SCIENCE, 2022, 43(17): 105-116.

[1]	黄天姿李瑞娟杨淑霞张璐梁锦王丹白俊青罗安伟. 电子束辐照对不同品种猕猴桃品质的影响[J]. 食品科学, 0, (): 0-0.
[2]	赵莹严龙飞严文静章建浩. 低温等离子体（PAW-DBD）对草莓冷杀菌效果及品质的影响[J]. 食品科学, 0, (): 0-0.
[3]	马琴，冯娟，田建文，刘军，李冬冬，张园园，刘敦华，李江阔. 采后1-甲基环丙烯与自发气调处理对冰温贮藏火柿软化及相关生理变化的影响[J]. 食品科学, 2022, 43(17): 231-239.
[4]	金思渊，谢晶. 蓝光协同茴香精油对鲜切苋菜的保鲜机理[J]. 食品科学, 2022, 43(17): 290-296.
[5]	黄天姿，李瑞娟，杨淑霞，张璐，梁锦，王丹，白俊青，罗安伟. 电子束辐照对不同品种猕猴桃品质的影响[J]. 食品科学, 2022, 43(17): 297-305.
[6]	卢玉慧李永才谭芸秀王小晶毕阳. 鼠李糖脂处理对早酥梨抗黑斑病的诱导作用及其机理[J]. 食品科学, 0, (): 0-0.
[7]	王永伦李兴杨苗林姿娜董晓博徐怀德. 不同干燥方式对真姬菇菌柄和菌盖挥发性风味物质的影响[J]. 食品科学, 0, (): 0-0.
[8]	刘佳欣，李灿婴，蒋超男，李伊涵，程园，葛永红. 外源褪黑素对‘南果梨’果实贮藏品质和细胞壁降解酶的影响[J]. 食品科学, 2022, 43(13): 155-162.
[9]	刘佳欣李灿婴蒋超男李伊涵程园葛永红. 外源褪黑素对南果梨果实贮藏品质和细胞壁降解酶的影响[J]. 食品科学, 0, (): 0-0.
[10]	宋聪慧郭水欢张寒彬史小强吴家锴詹丽娟. 褪黑素调控果蔬采后保鲜研究进展[J]. 食品科学, 0, (): 0-0.
[11]	吴帆陈楠吴雨卿倪元颖温馨. 肠道吸收细胞模型研究进展及其在类胡萝卜素上的应用[J]. 食品科学, 0, (): 0-0.
[12]	张凤娟滕建文韦保耀黄丽夏宁. 固态渗透预处理对冻干芒果加工过程减排、资源消耗及产品品质的影响[J]. 食品科学, 0, (): 0-0.
[13]	钟秋夏郑海英朱燕丽李晶陈汉城范小平. 百里香酚微胶囊的制备及其对草莓的保鲜效果[J]. 食品科学, 0, (): 0-0.
[14]	任爱清，邓珊，林芳，唐小闲，孟祥勇，张晓斌，段振华. 不同干燥处理对黑木耳粉理化特性和微观结构的影响[J]. 食品科学, 2022, 43(11): 75-81.
[15]	杨阳阳，刘志恬，李永才，毕阳，卢玉慧，谢鹏东. 吡啶-2,6-二羧酸处理对梨果采后黑斑病控制作用及其抑菌机理[J]. 食品科学, 2022, 43(11): 163-170.

低温等离子体活化水与介质阻挡放电联合处理对草莓冷杀菌效果及品质的影响

Effect of Combined Cold Plasma-Activated Water and Dielectric Barrier Discharge Treatment on the Sterilization and Quality of Strawberry

RichHTML

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价