猪肉剪切力的测定方法

食品科学 ›› 2012, Vol. 33 ›› Issue (21): 64-67.

猪肉剪切力的测定方法

王晓宇，周光宏*，徐幸莲，李春保

南京农业大学国家肉品质量安全控制工程技术研究中心

收稿日期:2011-09-06 修回日期:2012-10-22 出版日期:2012-11-15 发布日期:2012-11-09
通讯作者: 周光宏 E-mail:ghzhou@njau.edu.cn
基金资助:
肉类生产与加工质量安全控制技术

A Methodological Study of the Determination of Pork Warner-Bratzler Shear Force

Received:2011-09-06 Revised:2012-10-22 Online:2012-11-15 Published:2012-11-09

摘要/Abstract

摘要： 为建立可靠、规范的猪肉剪切力测定方法，研究不同加热中心温度(65～80℃)、水浴温度(70～80℃)、保温时间(0～20min)及冷却温度(0～25℃)对猪背最长肌剪切力值和蒸煮损失的影响。结果表明：猪肉的剪切力和蒸煮损失随着中心温度和水浴温度的升高、保温时间的延长而增加，冷却至0～4℃的肉样其剪切力值的变异系数最小，不同的预处理方法对猪肉剪切力的影响差异显著。综合而言，猪肉剪切力测定的预处理条件应为：水浴温度72℃，加热至中心温度70℃，不保温，煮后肉样放至0～4℃冷库中过夜。

关键词: 猪肉, 预处理, 剪切力

Abstract: An investigation into the effects of internal temperature, water-bath temperature, holding time and chilling temperature on the Warner-Bratzler shear force (WBSF) and cooking loss of pork longissimus dorsi muscle was studied with the aim of developing a reliable, standardized sample pretreatment approach for the determination of pork WBSF. Pork WBSF and cooking loss were positively related to internal temperature, water-bath temperature and holding time. WBSF values of pork samples chilled to a temperature between 0 ℃ and 4 ℃ showed maximum coefficient of variation. Different sample pretreatment methods had significantly different effects on pork WBSF. Taken together, the results of this study suggest that the sample pretreatment procedure for the determination of pork WBSF involves heating in a 72 ℃ water bath to an internal temperature of 70 ℃ and then immediately storage at 0—4 ℃ overnight.

Key words: pork, pretreatment, Warner-Braztler shear force (WBSF)

中图分类号:

TS251.51

王晓宇，周光宏*，徐幸莲，李春保 . 猪肉剪切力的测定方法[J]. 食品科学, 2012, 33(21): 64-67.

参考文献

[1] 周光宏, 李春保, 徐幸莲. 肉类食用品质评价方法研究进展[J]. 中国科技论文在线, 2007, 2(2):79.
[2]BREDAHL L, GRUNERT K G, FERTIN C. Relating consumer perceptions of pork quality to physical product characteristics[J]. Food Quality and Preference,1998,9(4):273-281.
[3] 周光宏. 肉品学[M]. 北京: 中国农业科技出版社, 1999.
[4] CAINE W R, AALHUS J L, Best D R, et al .Relationship of texture profile analysis and Warner-Bratzler shear force with sensory characteristics of beef rib steaks [J]. Meat Science, 2003 (64):333-339.
[5] PEACHEY B M, PURCHAS R W, DUIZER L M. Relationships between sensory and objective measures of meat tenderness of beef m.longissimus thoracis from bulls and steers [J]. Meat Science.2002-60:211-218.
[6] 刘兴余等.猪肉嫩度测定方法的改进[J].中国农业科学2007,40(1):167-172.
[7]李诚等.猪肉宰后冷却成熟过程中嫩度指标的相关性研究[J].食品科学,2009,30(17):164.
[8]丁武等. 质构仪穿透法测定肉制品嫩度的研究[J].农业工程学报, 2005, 21:138-141.
[9]C VASANTHI, V VENKATAVAMANUJAM, K DUSHYANTHAN. Effect of cooking temperature and time on the physico-chemical, histological and sensory properties of female carabeef (buffalo) meat [J].Meat Scienxe.2007(76):274-277.
[10]黄明等,热处理对猪肉食用品质的影响[J].食品科学,2009, 30(23):189.
[11]黄明等,热处理对牛肉剪切力值及蒸煮损失的影响[J].肉类工业,1999, 10(220):25.
[12]李超等,加热过程中肉嫩度变化的研究[J],食品科学,2009, 30(11):263.
[13] BENDALL J R, RESTALL D J. The cooking of single myofibres, small myofibre bundles and muscle strips from beef M. psoas and M.sternomandibularis muscles at varying heating rates and temperatures [J]. Meat Science, 1983(8): 93-117.
[14] BOUTON P E, HARRIS P V. The effects of cooking temperature and time on some mechanical properties of meat[J]. Journal of Food Science,1972, 37: 140-144.
[15] BARBUT S, FINDLAY J C. Influence of sodium, potassium and magnesium chloride on thermal properties of beef muscle[J]. Journal of Food Science, 1991, 56: 180-182.
[16] SIMS T J, BAILEY A J. Structural aspects of cooked meat[M].Cambridge: The Royal Society of Chemistry, 1992: 106-127.
[17] BRUNTON N P, LYNG J G, ZHANG L, et al. The use of dielectric properties and other physical analyses for assessing protein denaturation in beef biceps femoris muscle during cooking from 5 to 85℃[J]. Meat Science, 2006, 72: 236-244.
[18]王振宇等,热处理下的猪肉蛋白质特性[J].食品科学,2008,29(05):74-75.
[19]S D SHACKELFORD,T L WHEELER,M KOOHMARAIE.Evaluation of slice shear as an objective method of assessing beef longissimus tenderness[J].Animal Science,1999,77(10):2695.